AVSPARE.COM
parts catalog

BAR 9V9829 - Caterpillar



9V9829 BAR Caterpillar parts 916, 926, 936, 936F, CS-643, G936, IT28 BAR
Rating:
73
Alternative (cross code) number:
CA9V9829
9V-9829
9V9829
Caterpillar 9V9829 BAR
Weight: 0.20 pounds 0 kg.

Buy BAR 9V9829 Caterpillar genuine, new aftermarket tractor parts with delivery
INTEGRATED TOOLCARRIER, WHEEL LOADER,

Compatible equipment models: 9V9829:

INTEGRATED TOOLCARRIER  IT28  
VIBRATORY COMPACTOR  CS-643  
WHEEL LOADER  916   926   936   936F   G936   Caterpillar
Number on catalog scheme: 2
 
  For full view, you need register

Information:

(1) Install shims as required to provide end float in the bearing assemblies of ... 0.05-0.16 mm (0.002-0.006in.)Bearing Adjustment
The output transfer drive bearings are adjusted with shims located between the casing and bearing housings. The adjustment procedure is the same for each bearing assembly so only the idler gear bearing adjustment is described.1. Lie the casing flat and install bearing housing (8) without any shims or O-ring seal. Use two bolts equally spaced (without washers).2. Turn the gear by hand while tightening the bolts slowly and evenly until all end float in the bearing assembly is taken up. When all end float is taken up the effort required to turn the gear will start to increase. This should correspond to a torque of approximately 1.5 N m (13lb.in.) on the two bolts.3. Observe the bearing rollers as the gear is being turned. The rollers should all be turning on their own axes. If the rollers are skidding end float is still present in the assembly.4. Measure the clearance between the housing (8) and the casing (6) at two positions, directly opposite each other. Average these two measurements.5. Remove the housing (8) and make up a shim pack whose thickness equals the average measured clearance plus 0.10mm (0.004in.)6. Install the housing with shims and O-ring seal. Tighten the bolts to the specified torque.7. Turn the gear by hand while observing the bearing rollers. The rollers should be skidding if end float is present in the assembly. If the gearbox is standing vertically (as illustrated) the rollers at the top of the bearing should be clearly seen to be skidding. If the gearbox is standing horizontally skidding of the rollers will be more general but should still be quite easily detected. If skidding is not clearly visible it is likely that insufficient end float is present.(4) When assembling input boss (2) to gear (3) or gear (7) to gear (10) use 2U2856 retaining compound between the mating faces.(5) Torque for bolts ... 255-285 N m (190-210lb.ft.) Install with 2U2855 threadlock.Wirelock after assembly.(9) Torque for bolts ... 255-285 N m (190-210lb.ft.) Install with 2U2855 threadlock.Wirelock after assembly.

Cat SIS web machinery list:

Caterpillar parts catalog
IT28 INTEGRATED TOOLCARRIER 8JB00001-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
1T18 INTEGRATED TOOLCARRIER 7ZB00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 45Z00001-03056 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 4NB00001-02075 (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 8JB00001-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
1T18 INTEGRATED TOOLCARRIER 7ZB00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 45Z00001-03056 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 4NB00001-02075 (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 33Z00001-03090 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 94Z00001-02208 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 2XB00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 2KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18 INTEGRATED TOOLCARRIER 9NB00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 33Z00001-03090 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 94Z00001-02208 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 2XB00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 2KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18 INTEGRATED TOOLCARRIER 9NB00001-UP (MACHINE) POWERED BY 3204 ENGINE
G936 WHEEL LOADER 3HD00001-UP (MACHINE) POWERED BY 3304 ENGINE
G926 WHEEL LOADER 1SD00001-00073 (MACHINE) POWERED BY 3204 ENGINE
G916 WHEEL LOADER 5GD00001-00047 (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 1HF00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 4ZD00001-UP (MACHINE) POWERED BY 3204 ENGINE
926E WHEEL LOADER 94Z02209-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 33Z03091-UP (MACHINE) POWERED BY 3304 ENGINE
IT28 INTEGRATED TOOLCARRIER 8JB00001-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
1T18 INTEGRATED TOOLCARRIER 7ZB00001-UP (MACHINE) POWERED BY 3204 ENGINE
G936 WHEEL LOADER 4ND00001-UP (MACHINE) POWERED BY 3304 ENGINE
936 WHEEL LOADER 45Z00001-03056 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 4NB00001-02075 (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 5SD00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 1DF00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 45Z03057-UP (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 4NB02076-UP (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 8JB00001-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
1T18 INTEGRATED TOOLCARRIER 7ZB00001-UP (MACHINE) POWERED BY 3204 ENGINE
G936 WHEEL LOADER 4ND00001-UP (MACHINE) POWERED BY 3304 ENGINE
936 WHEEL LOADER 45Z00001-03056 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 4NB00001-02075 (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 5SD00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 1DF00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 45Z03057-UP (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 4NB02076-UP (MACHINE) POWERED BY 3204 ENGINE
CS-643, CP-643, CS-653, CP-653 VIBRATORY COMPACTOR 7FD00001-UP (MACHINE) POWERED BY 3304 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 5SD00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 1DF00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 45Z03057-UP (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 4NB02076-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 5SD00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 1DF00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 45Z03057-UP (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 4NB02076-UP (MACHINE) POWERED BY 3204 ENGINE
926E WHEEL LOADER 8NB02452-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB02503-UP (MACHINE) POWERED BY 3304 ENGINE
IT28B INTEGRATED TOOLCARRIER 1JK00430-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 2NJ00340-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 5KC01849-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 4SB00001-01623 (MACHINE) POWERED BY 3304 ENGINE
916 WHEEL LOADER 5KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB01624-02502 (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 8NB01542-02451 (MACHINE) POWERED BY 3204 ENGINE
926E WHEEL LOADER 8NB02452-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB02503-UP (MACHINE) POWERED BY 3304 ENGINE
IT28B INTEGRATED TOOLCARRIER 1JK00430-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 2NJ00340-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 5KC01849-UP (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 8JB00001-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
1T18 INTEGRATED TOOLCARRIER 7ZB00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 45Z00001-03056 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 4NB00001-02075 (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 8JB00001-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
1T18 INTEGRATED TOOLCARRIER 7ZB00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 45Z00001-03056 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 4NB00001-02075 (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 33Z00001-03090 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 94Z00001-02208 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 2XB00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 33Z00001-03090 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 94Z00001-02208 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 2XB00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 2KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18 INTEGRATED TOOLCARRIER 9NB00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 33Z00001-03090 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 94Z00001-02208 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 2XB00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 2KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18 INTEGRATED TOOLCARRIER 9NB00001-UP (MACHINE) POWERED BY 3204 ENGINE
G936 WHEEL LOADER 3HD00001-UP (MACHINE) POWERED BY 3304 ENGINE
G926 WHEEL LOADER 1SD00001-00073 (MACHINE) POWERED BY 3204 ENGINE
G916 WHEEL LOADER 5GD00001-00047 (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 1HF00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 4ZD00001-UP (MACHINE) POWERED BY 3204 ENGINE
926E WHEEL LOADER 94Z02209-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 33Z03091-UP (MACHINE) POWERED BY 3304 ENGINE
IT28 INTEGRATED TOOLCARRIER 8JB00001-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
1T18 INTEGRATED TOOLCARRIER 7ZB00001-UP (MACHINE) POWERED BY 3204 ENGINE
G936 WHEEL LOADER 4ND00001-UP (MACHINE) POWERED BY 3304 ENGINE
936 WHEEL LOADER 45Z00001-03056 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 4NB00001-02075 (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 5SD00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 1DF00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 45Z03057-UP (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 4NB02076-UP (MACHINE) POWERED BY 3204 ENGINE
IT28 INTEGRATED TOOLCARRIER 8JB00001-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
1T18 INTEGRATED TOOLCARRIER 7ZB00001-UP (MACHINE) POWERED BY 3204 ENGINE
G936 WHEEL LOADER 4ND00001-UP (MACHINE) POWERED BY 3304 ENGINE
936 WHEEL LOADER 45Z00001-03056 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 4NB00001-02075 (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 5SD00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 1DF00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 45Z03057-UP (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 4NB02076-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 5SD00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 1DF00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 45Z03057-UP (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 4NB02076-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 9WB00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT28B INTEGRATED TOOLCARRIER 5SD00001-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 1DF00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 45Z03057-UP (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 4NB02076-UP (MACHINE) POWERED BY 3204 ENGINE
936F WHEEL LOADER 8AJ00001-UP (MACHINE) POWERED BY 3304 ENGINE
936F WHEEL LOADER 4TK00001-UP (MACHINE) POWERED BY 3304 ENGINE
G936 WHEEL LOADER 8ED00001-UP (MACHINE) POWERED BY 3304 ENGINE
936 WHEEL LOADER 4SB00001-01623 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 8NB00001-01541 (MACHINE) POWERED BY 3204 ENGINE
G936 WHEEL LOADER 8ED00001-UP (MACHINE) POWERED BY 3304 ENGINE
936 WHEEL LOADER 4SB00001-01623 (MACHINE) POWERED BY 3304 ENGINE
926 WHEEL LOADER 8NB00001-01541 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 5KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 4SB00001-01623 (MACHINE) POWERED BY 3304 ENGINE
916 WHEEL LOADER 5KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 4SB00001-01623 (MACHINE) POWERED BY 3304 ENGINE
916 WHEEL LOADER 5KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB01624-02502 (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 8NB01542-02451 (MACHINE) POWERED BY 3204 ENGINE
926E WHEEL LOADER 8NB02452-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB02503-UP (MACHINE) POWERED BY 3304 ENGINE
IT28B INTEGRATED TOOLCARRIER 1JK00430-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 2NJ00340-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 5KC01849-UP (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 4SB00001-01623 (MACHINE) POWERED BY 3304 ENGINE
916 WHEEL LOADER 5KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB01624-02502 (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 8NB01542-02451 (MACHINE) POWERED BY 3204 ENGINE
936 WHEEL LOADER 4SB00001-01623 (MACHINE) POWERED BY 3304 ENGINE
936E WHEEL LOADER 4SB01624-02502 (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 8NB01542-02451 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 5KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB01624-02502 (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 8NB01542-02451 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 5KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB01624-02502 (MACHINE) POWERED BY 3304 ENGINE
926E WHEEL LOADER 8NB01542-02451 (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 5KC00001-UP (MACHINE) POWERED BY 3204 ENGINE
926E WHEEL LOADER 8NB02452-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB02503-UP (MACHINE) POWERED BY 3304 ENGINE
IT28B INTEGRATED TOOLCARRIER 1JK00430-UP (MACHINE) POWERED BY 3204 ENGINE
IT18B INTEGRATED TOOLCARRIER 2NJ00340-UP (MACHINE) POWERED BY 3204 ENGINE
916 WHEEL LOADER 5KC01849-UP (MACHINE) POWERED BY 3204 ENGINE
926E WHEEL LOADER 8NB02452-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB02503-UP (MACHINE) POWERED BY 3304 ENGINE
916 WHEEL LOADER 5KC01849-UP (MACHINE) POWERED BY 3204 ENGINE
926E WHEEL LOADER 8NB02452-UP (MACHINE) POWERED BY 3204 ENGINE
936E WHEEL LOADER 4SB02503-UP (MACHINE) POWERED BY 3304 ENGINE
916 WHEEL LOADER 5KC01849-UP (MACHINE) POWERED BY 3204 ENGINE
936F WHEEL LOADER 9MK00001-UP (MACHINE) POWERED BY 3304 ENGINE


Parts bar Caterpillar catalog:

5F4764 BAR-PRY
120B, 120G, 120H, 120M, 12G, 12H, 12M, 130G, 135H, 140G, 140H, 140K, 140M, 143H, 14G, 14H, 14H NA, 160G, 160H, 160K, 160M, 163H, 16G, 16H, 16H NA, 16M, 235, 245, 307C, 311C, 3126, 3304, 3304B, 3306, 3...
4Y0955 BAR
936, 936F, G936
9V2599 BAR
926, 988F II
5V7011 BAR
936, 936F, G936
9V1165 BAR
936, 936F, G936
Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.