AVSPARE.COM
parts catalog

CARRIER AS 9V9405 - Caterpillar



9V9405 CARRIER AS Caterpillar parts 215B CARRIER
Rating:
37
Alternative (cross code) number:
CA9V9405
9V-9405
9V9405
Caterpillar 9V9405 CARRIER AS
Weight: 48 pounds 21 kg.

Buy CARRIER AS 9V9405 Caterpillar genuine, new aftermarket tractor parts with delivery
EXCAVATOR,

Compatible equipment models: 9V9405:

EXCAVATOR  215B   Caterpillar
Number on catalog scheme: 15
 
  For full view, you need register

Information:


Illustration 1 g00531413
The GSC uses the run relay (RR) in order to activate the start aid system. The GSC provides a set of contacts of the run relay (RR1) for the customer's use. The RR is located within the relay module. The starting aid switch (SAS) is located on the front panel.The GSC activates the RR during engine cranking and running.Note: Whenever the GSC activates or the GSC attempts to activate the RR, "K5" is shown on the lower display. When the RR is not activated, "K5" is not shown.The possible cause of a CID 0445 FMI 12 is an open coil or a shorted coil of the RR.The system responses to this diagnostic code are listed below.
If a CID 0445 FMI 12 occurs and the RR is activated, the SAS will be disabled. Any customer's equipment on RM-23 of the relay module will be disabled.
If a CID 0445 FMI 12 occurs and the RR is not activated, the SAS will not be enabled. Any customer's equipment on RM-23 of the relay module will not be activated.The GSC treats a CID 0445 FMI 12 as an alarm fault. Active alarm faults are shown on the display when the "Alarm Codes" key is pressed. Also, the engine control switch (ECS) must be in any position except the OFF/RESET position. Clear the diagnostic code from the fault log after troubleshooting is complete.This troubleshooting procedure is for an active CID 0445 FMI 12 or the troubleshooting procedure is for an inactive CID 0445 FMI 12.Test Step 1. CHECK THE STATUS OF THE DIAGNOSTIC CODE.
Turn the ECS to the OFF/RESET position and then turn the ECS to the STOP position.
Press the "Alarm Codes" key.
Observe the upper display. Check that the CID 0445 FMI 12 is active.
If the diagnostic code is not active, enter the Service Mode. View the fault log for a OP1. Check that the diagnostic code is inactive.Expected Result:A CID 0445 FMI 12 is displayed as an active diagnostic code or CID 0445 FMI 12 is displayed as an inactive diagnostic code.Results:
OK - The CID 0445 FMI 12 is active or the CID 0445 FMI 12 is inactive. Proceed to test step 2.
NOT OK - The CID 0445 FMI 12 has not occurred. The diagnostic code is not active and the diagnostic code is not inactive. Stop.Test Step 2. CHECK THE INTERNAL CABLE OF THE RELAY MODULE.Note: Only open the relay module in a dry environment. If the inspection and repair takes more than approximately twenty minutes replace the desiccant bag in the GSC housing. See Testing And Adjusting, "Relay Module - Replace".
Turn the ECS to the OFF/RESET position.
Disconnect the battery negative cable.
Temporarily, remove the relay module from the GSC. See Testing And Adjusting, "Relay Module - Replace".
Check the cable that attaches the relay module to the GSC.Expected Result:The cable should be firmly seated in the connector. The clamp should be

Caterpillar parts catalog:

Caterpillar parts catalog
215B EXCAVATOR 2XC00001-UP (MACHINE) POWERED BY 3204 ENGINE


Parts carrier Caterpillar catalog:

3333053 CARRIER
315D L, 316E L, 318D L, 318D2 L
3099259 CARRIER
304C CR, 305D CR, 305E
5W7411 CARRIER
205, 205B, 211B, 213B
5W7403 CARRIER
205, 205B, 211B, 213B
5W7400 CARRIER
205, 205B, 211B, 213B
6C0739 CARRIER AS
215, 215B, 215C
Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.