AVSPARE.COM
parts catalog

Element, Hytrel 72020017 - Caterpillar



72020017 Element, Hytrel Caterpillar parts CS-431, CS-433, TSF-54, TSM-54 Element
Rating:
59
Alternative (cross code) number:
CA72020017
7202-0017
72020017
Caterpillar 72020017 Element, Hytrel

Buy Element, Hytrel 72020017 Caterpillar genuine, new aftermarket tractor parts with delivery
VIBRATORY COMPACTOR,

Compatible equipment models: 72020017:

VIBRATORY COMPACTOR  CS-431   CS-433   TSF-54   TSM-54   Caterpillar
Number on catalog scheme: 3
 
  For full view, you need register

Information:


Illustration 1 g01775574
Schematic of the solenoid valve (No. 5)This diagnostic code is associated with the solenoid valve (No. 5). This diagnostic code is recorded when the ECM reads the current of the solenoid as being above normal. There is a short to ground.The possible causes of this diagnostic code are listed:
The signal circuit of the solenoid is shorted to ground.
The solenoid has failed.
The ECM has failed. This is unlikely.System Response:When this diagnostic code is active, the power train ECM will turn off the current to the failed solenoid. Operation in the gears that use this solenoid will not be allowed by the power train ECM.Note: Ensure that the CID 1405 FMI 06 is on hold and that the diagnostic code indicator shows "SERV CODE".Note: The following test procedure may create other diagnostic codes. Clear the diagnostic codes when the original diagnostic code is corrected.Test Step 1. CHECK THE SOLENOID.
Turn the disconnect switch to the ON position.
Turn the key start switch to the ON position. Note: Do not start the engine.
Ensure that the CID 1405 FMI 06 is on hold.
Observe the status of the diagnostic code. The diagnostic code will be active or the diagnostic code will not be active.
Disconnect the solenoid with the active diagnostic code from the machine harness.Expected Result:The diagnostic code is no longer shown when the solenoid is disconnected.Results:
OK - The diagnostic code is no longer showing. The circuit is correct.Repair: The solenoid has failed. Repeat this test "CHECK THE SOLENOID" in order to verify the solenoid failure. Replace the solenoid.STOP
NOT OK - The diagnostic code remains present. The diagnostic code remains active. Proceed to Test Step 2.Test Step 2. CHECK THE SOLENOID CIRCUIT FOR A SHORT TO GROUND
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness from the solenoid.
Disconnect the machine harness connectors J1 and J2 from the ECM.
At the machine harness connector, measure the resistance from the signal contact J2-8 (wire 902-BR) to all possible sources of ground.Expected Result:There should be greater than 5000 ohms resistance for each measurement.Results:
OK - The resistance measurement is greater than 5000 ohms for each measurement. The machine harness is correct. Proceed to Test Step 3.
NOT OK - The resistance is not correct. There is a short in the machine harness.Repair: The short is between wire (902-BR) and the circuit with the low resistance measurement. Repair the machine harness or replace the machine harness.STOPTest Step 3. CHECK IF THE DIAGNOSTIC CODE REMAINS.
Perform the following:
Inspect the contacts of the harness connectors.
Clean the contacts of the harness connectors.
Reconnect all harness connectors.
Turn the disconnect switch to the ON position.
Turn the key start switch to the ON position.
Enter service mode of the Caterpillar Monitoring System and clear all inactive diagnostic codes.
Operate the machine.
Determine if CID 1405 FMI 06 for the solenoid is present. "SERV CODE" is showing.Expected Result:The CID 1405 FMI 06 for the solenoid is not present. "SERV CODE" is not showing.Results:
OK - The diagnostic code is not present. The diagnostic code does not exist

Caterpillar parts catalog:

Caterpillar parts catalog
CP-323 VIBRATORY COMPACTOR 6JD00001-00065 (MACHINE) POWERED BY 4219D ENGINE
CS-433 & CP-433 VIBRATORY COMPACTOR 6ND00001-UP (MACHINE) POWERED BY 4276D ENGINE
TSM-54 VIBRATORY COMPACTOR 7LD00001-UP (MACHINE) POWERED BY F2L-511D ENGINE
TSF-54 VIBRATORY COMPACTOR 7KD00001-UP (MACHINE) POWERED BY F2L-511D ENGINE
CS-431 VIBRATORY COMPACTOR 6MD00001-UP (MACHINE) POWERED BY 4219D/4239D ENGINES


Parts element Caterpillar catalog:

Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.