AVSPARE.COM
parts catalog

FILTER GP-FUMES DISPOSAL 3156631 - Caterpillar



3156631 FILTER GP-FUMES DISPOSAL Caterpillar parts C15, TH35-C15T FILTER
Rating:
78
Alternative (cross code) number:
CA3156631
315-6631
3156631
Caterpillar 3156631 FILTER GP-FUMES DISPOSAL

Buy FILTER GP-FUMES DISPOSAL 3156631 Caterpillar genuine, new aftermarket tractor parts with delivery
PETROLEUM PACKAGE, TRUCK ENGINE,

Compatible equipment models: 3156631:

PETROLEUM PACKAGE  TH35-C15T  
TRUCK ENGINE  C15   Caterpillar
Number on catalog scheme:
  
  For full view, you need register

Information:


Illustration 1 g02065975
Schematic of the "Boom Down Control Pressure" SensorThis diagnostic code is recorded when the Machine ECM reads the voltage of the circuit for the "Boom Down Control Pressure" Sensor as being below normal. The signal circuit of the sensor may be shorted to ground.The possible causes of this diagnostic code are listed below:
The signal circuit for the pressure sensor is shorted to ground.
The pressure sensor has failed.
The Machine ECM has failed. This is unlikely. Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear the diagnostic codes when the original diagnostic code has been corrected.Note: Ensure that the diagnostic code of CID 3012 FMI 04 is active before performing this procedure. Test Step 1. CHECK THE PRESSURE SENSOR.
Turn the disconnect switch and the key start switch to the ON position.
Ensure that the diagnostic code is active.
Observe the status of the diagnostic code. Disconnect the pressure sensor from the machine harness.Expected Result:The CID 3012 FMI 04 diagnostic code remains active. Results:
OK - The diagnostic code remains active. The pressure sensor is correct. Proceed to Test Step 2.
NOT OK - The diagnostic code is no longer active. The pressure sensor has failed.Repair: Replace the pressure sensor.STOPTest Step 2. CHECK THE WIRING HARNESS OF THE "BOOM DOWN CONTROL PRESSURE" SENSOR FOR A SHORT TO GROUND.
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness from the pressure sensor.
Disconnect machine harness connectors from the Machine ECM.
At the machine harness connector for the ECM, measure the resistance from the signal contact J1-17 (wire M844-OR) of the machine harness to all possible sources of ground. Measure the resistance to all contacts that are used in the J1 and J2 harness connectors.Expected Result:Each resistance measurement should be greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 3.
NOT OK - One or more resistance measurements are not correct. There is a short in the machine harness. The short is between signal contact J1-17 (wire M844-OR) and the circuit with the low resistance measurement. Repair the machine harness or replace the machine harness.STOPTest Step 3. CHECK IF THE DIAGNOSTIC CODE REMAINS.
Inspect the contacts of the harness connectors and clean the contacts.
Reconnect all harness connectors.
Turn the disconnect switch and the key start switch to the ON position.
Enter the service mode of the Monitoring System and clear all of the inactive diagnostic codes.
Operate the machine.
Check the status of the CID 3012 FMI 04.Expected Result:The CID 3012 FMI 04 is not active. Results:
YES - The CID 3012 FMI 04 is not active. The diagnostic code does not exist at this time. The initial diagnostic code was probably caused by a poor electrical connection or a short at one of the harness connectors that was disconnected and reconnected. Resume normal machine operation.STOP
NO - The CID 3012 FMI 04 is active. The diagnostic code has not been corrected. It is unlikely that the ECM has

Caterpillar SIS machinery equipment:

Caterpillar SIS

Caterpillar parts catalog:

Caterpillar parts catalog
C15 On-highway Engine SDP00001-UP
TH35-C15T Petroleum Package PBL00001-UP POWERED BY TH35-C15T PETROLEUM


Parts filter Caterpillar catalog:

1261817 FILTER-OIL
414E, 416C, 416D, 416E, 420D, 420E, 422E, 424B, 424B HD, 424D, 426C, 428C, 428D, 428E, 430D, 430E, 432D, 432E, 434E, 436C, 438C, 438D, 442D, 442E, 444E, 446B, 446D, 834G, 834H, 834K, 836G, 836H, 836K,...
1R1808 FILTER-ENGINE OIL
120H, 12H, 12M 2, 12M 3, 12M 3 AWD, 135H, 140H, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14H, 14M, 160H, 160M, 160M 2, 160M 3, 160M 3 AWD, 163H, 16G, 16H NA, 16M, 2290, 2390, 2391, 2491, 24H, 24M, 2590...
1112721 FILTER
16H NA, 24H, 3116, 3126, 3406, 3406B, 3406C, 3406E, 3408, 3408B, 3408C, 3408E, 3412, 3412C, 3412D, 3412E, 3516, 365C, 365C L, 365C L MH, 385C, 385C FS, 385C L, 385C L MH, 5110B, 589, 631D, 631E, 631G,...
1446691 FILTER-OIL
515, 518C, 525, 525D, 528B, 530B, 535D, 545D, 725, 730, 735, 740, 924K, 930K, 938K, AP-1000, AP-1000B, AP-1050, AP-1055B, AP-650B, AP-800, AP-800C, AP-800D, AP-900B, BG-225B, BG-225C, BG-2455C, BG-245...
3261641 FILTER AS-WATER SEP & FUEL
345C, 345C L, 345C MH, 345D, 345D L, 349D, 349D L, 365C, 365C L, 365C L MH, 385C, 385C FS, 385C L, 385C L MH, 631E, C-12, C-15, C-16, C-9, C11, C13, C15, C15 I6, C18, C18 I6, C27, C32, C7, C9, R1300G,...
3017856 FILTER AS-DIESEL PARTICULATE
C13, C15, C9, TH31-E61, TH35-C13T, TH35-C15T
3047502 FILTER AS-DIESEL PARTICULATE
C13, C15, C9, TH31-E61, TH35-C13T, TH35-C15T
2918519 FILTER AS-DIESEL PARTICULATE
C13, C15, TH35-C13T, TH35-C15T
2900045 FILTER AS-DIESEL PARTICULATE
C13, C15, TH35-C13T, TH35-C15T
2568753 FILTER AS-WATER SEP & FUEL
C13, C15, TH35-C13T, TH35-C15T
1391537 FILTER ELEMENT AS-OIL
5230B, 527, 578, 583R, 621K, 623K, 623K LRC, 627K, 627K LRC, 725, 730, 735, 950K, 962K, 966K, 972K, 980K, 993K, C9, CX35-P800, D10N, D10R, D10T, D10T2, D11T, D5N, D5R LGP, D6M, D6N, D6N LGP, D6N OEM, ...
Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.