AVSPARE.COM
parts catalog

HOSE AS 3535191 - Caterpillar



3535191 HOSE AS Caterpillar parts 924K, 930K, 938K HOSE
Rating:
62
Alternative (cross code) number:
CA3535191
353-5191
3535191
Caterpillar 3535191 HOSE AS
Weight: 7 pounds 3 kg.

Buy HOSE AS 3535191 Caterpillar genuine, new aftermarket tractor parts with delivery
WHEEL LOADER,

Compatible equipment models: 3535191:

WHEEL LOADER  924K   930K   938K   Caterpillar
Number on catalog scheme: 1
 
  For full view, you need register

Information:


Illustration 1 g00447749
Number 6 Clutch Solenoid Modulating Valve SchematicCID 0636 FMI 06 service code is recorded when the power train electronic control module (ECM) reads the current of the solenoid circuit as above normal (short to ground). Note: Ensure that the service code CID 0636 FMI 06 for the solenoid is active. Before performing this procedure, refer to table 1 in order to determine the connector contact number and the wire number that corresponds to the failed circuit.
Table 1
Solenoid Valve Information    
Fault    Connector Contact No. (1)    Wire No.    
Number 6 Clutch Solenoid Modulating Valve (First Speed)     J2-2     901-WH    
( 1 ) Connector contact number of the power train ECM.Note: All of the solenoid return lines are joined and connect to contacts J1-7 and J2-3 (wire 975-WH).Note: The approximate coil resistance of the clutch solenoid modulating valves is 5 to 15 Ohms.Note: Access to the clutch solenoid modulating valve may require removal of the left rear platform support bracket. Replacement of the clutch solenoid modulating valve may require removal of the cab.
Check the resistance of the solenoid.
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness from the suspected solenoid.
At the clutch solenoid modulating valve, measure the resistance between the two contacts of the solenoid connector.Expected Result: The resistance should be between 5 - 15 Ohms.Results:
OK - The solenoid resistance is correct. Proceed to Step 2.
NOT OK - The solenoid has failed. Replace the solenoid. STOP.
Check the solenoid for a short to ground.The disconnect switch and the key start switch remain in the OFF position. The solenoid remains disconnected from the machine harness.
Measure the resistance from each solenoid contact to frame ground.Expected Result: Each resistance should be greater than 5000 Ohms.Results:
OK - The solenoid and the solenoid harness are correct. The fault is in the machine harness. Proceed to Step 3.
NOT OK - The solenoid has failed. Replace the solenoid. STOP.
Check the machine harness for a short to ground.The machine harness remains disconnected from the solenoid.
The disconnect switch and the key start switch remain in the OFF position.
Disconnect the machine harness connectors J1 and J2 from the power train ECM.
At machine harness connector J1 or J2, measure the resistance from the solenoid signal contact (refer to table 1) to all possible sources of ground. The following contacts are possible ground sources: J1-2, J1-5, J1-7, J1-15, J1-16, J2-3 and frame ground.Expected Result: Each resistance should be greater than 5000 Ohms.Results:
OK - The machine harness is correct. Proceed to Step 4.
NOT OK - There is a short in the machine harness. The short is between the wire for the solenoid signal (refer to table 1) and the circuit with the low resistance measurement. Repair the machine harness or replace the machine harness. STOP.
Check if the fault is still present.
Inspect the contacts and clean the contacts of the harness connectors.
Reconnect all harness connectors.
Turn the disconnect switch and the key start switch to the ON position.
Operate the machine.
Stop the machine

Cat SIS web machinery list:

Caterpillar parts catalog
930M Small Wheel Loader HEY00001-UP (MACHINE) POWERED BY C7.1 Engine
930K ADL (Air Deployable Loader) HEG00001-UP (MACHINE) POWERED BY C7.1 Engine
924K Wheel Loader PWR00001-UP (MACHINE) POWERED BY C6.6 Engine
930K Wheel Loader RHN00001-UP (MACHINE) POWERED BY C6.6 Engine
938K Wheel Loader SWL00001-UP (MACHINE) POWERED BY C6.6 Engine
924K Small Wheel Loader ENC00001-UP (MACHINE) POWERED BY C7.1 Engine
924K Small Wheel Loader HJF00001-UP (MACHINE) POWERED BY C7.1 Engine
930K Small Wheel Loader DYB00001-UP (MACHINE) POWERED BY C7.1 Engine
930K Small Wheel Loader EYE00001-UP (MACHINE) POWERED BY C7.1 Engine
938K Small Wheel Loader HFW00001-UP (MACHINE) POWERED BY C7.1 Engine
938K Small Wheel Loader XXT00001-UP (MACHINE) POWERED BY C7.1 Engine
926M Small Wheel Loader LTE00001-UP (MACHINE) POWERED BY C7.1 Engine
930M Small Wheel Loader KTG00001-UP (MACHINE) POWERED BY C7.1 Engine
938M Small Wheel Loader J3R00001-UP (MACHINE) POWERED BY C7.1 Engine
938K Small Wheel Loader W8K00001-UP (MACHINE) POWERED BY C7.1 Engine
930K Small Wheel Loader FRK00001-UP (MACHINE) POWERED BY C7.1 Engine
924K Small Wheel Loader SNZ00001-UP (MACHINE) POWERED BY C7.1 Engine
938K Small Wheel Loader REP00001-UP (MACHINE) POWERED BY C7.1 Engine
924K Small Wheel Loader KW400001-UP (MACHINE) POWERED BY C7.1 Engine
930K Small Wheel Loader P3K00001-UP (MACHINE) POWERED BY C7.1 Engine


Parts hose Caterpillar catalog:

5P1442 HOSE
120B, 120G, 120H, 120H ES, 120H NA, 120M, 120M 2, 12G, 12M, 12M 2, 12M 3, 12M 3 AWD, 130G, 135H NA, 140B, 140G, 140M, 140M 2, 140M 3, 140M 3 AWD, 14G, 14M, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 215, ...
5P0767 HOSE
1090, 1190, 1190T, 120G, 1290T, 1390, 140G, 215, 215B, 215C, 215D, 225, 225D, 227, 229, 2290, 229D, 231D, 235, 235B, 235C, 235D, 236D, 2384C, 2390, 2391, 242D, 245, 245B, 245D, 246D, 2470C, 2484C, 249...
5P1506 HOSE
3114, 3116, 3176, 3176B, 330 L, 3304, 3306, 3406, 3408, 3412, 3412C, 350, 375, 414E, 416B, 416C, 416D, 416E, 420D, 420E, 422E, 424D, 426B, 426C, 428B, 428C, 428D, 428E, 430D, 430E, 432D, 432E, 434E, 4...
8C3681 HOSE
120K, 120K 2, 120M, 120M 2, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 140G, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 16H, 16H NA, 225D, 231D, 236D, 242D, 2...
5P0743 HOSE
120K, 120K 2, 120M, 12K, 12M, 140G, 140K, 140K 2, 140M, 160K, 160M, 16M, 216, 228, 236, 236B, 236D, 242B, 242D, 246D, 247, 247B, 248, 257D, 259D, 262D, 267, 267B, 268B, 272D, 272D XHP, 277D, 279D, 287...
1945171 HOSE
120M, 120M 2, 12M, 12M 2, 12M 3, 12M 3 AWD, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 216, 216B, 216B3, 226B, 226B3, 228, 232B, 236, 236B, 236B3, 236D, 242B, 242B3,...
9X2133 HOSE
120K, 120K 2, 120M, 120M 2, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 303, 303.5C, 303.5D, 303.5E, 303C CR, 3...
6V8523 HOSE
1090, 1190, 1190T, 120K, 120K 2, 120M, 120M 2, 1290T, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 1390, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 24M, 30...
5T9986 HOSE AS
120G, 120H, 120H ES, 120H NA, 120K, 120K 2, 12G, 12H, 12H ES, 12H NA, 12K, 130G, 135H, 135H NA, 140G, 140H, 140H ES, 140H NA, 140K, 140K 2, 143H, 160G, 160H, 160H ES, 160H NA, 160K, 163H, 163H NA, 16G...
9W3008 HOSE AS
515, 525, 578, 615C, 924G, 924GZ, 924H, 924K, 928HZ, 930G, 930K, 938H, 938K, D9N
8W0125 HOSE AS
120G, 12G, 12H, 12H ES, 12H NA, 130G, 140G, 140H, 140H ES, 140H NA, 143H, 160G, 160H, 160H ES, 160H NA, 163H NA, 824G, 824G II, 824H, 825G, 825G II, 825H, 924K, 930K, D3K XL
5T9686 HOSE AS
140M, 14G, 14H, 14H NA, 160M, 16H, 16H NA, 16M, 615C, 924G, 924H, 924K, 928HZ, 930G, 930K, 938K, 990H, 992K, D11R
3759923 HOSE AS
924K, 930K, 938K
3507584 HOSE AS
924K, 930K, 938K
3465119 HOSE AS
924K, 930K, 938K
3465108 HOSE AS
924K, 930K, 938K
3465105 HOSE AS
924K, 930K, 938K
3904484 HOSE AS
924K, 930K, 938K
3772084 HOSE AS
924K, 930K, 938K
3594523 HOSE AS
924K, 930K, 938K
3487720 HOSE AS
924K, 930K, 938K
3487719 HOSE AS
924K, 930K, 938K
Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.