AVSPARE.COM
parts catalog

OPTION AR-PRECLEANER 3534196 - Caterpillar



3534196 OPTION AR-PRECLEANER Caterpillar parts 854K, 992K OPTION
Rating:
36
Alternative (cross code) number:
CA3534196
353-4196
3534196
Caterpillar 3534196 OPTION AR-PRECLEANER

Buy OPTION AR-PRECLEANER 3534196 Caterpillar genuine, new aftermarket tractor parts with delivery
WHEEL DOZER, WHEEL LOADER,

Compatible equipment models: 3534196:

WHEEL DOZER  854K  
WHEEL LOADER  992K   Caterpillar
  For full view, you need register

Information:

Specifications
Table 1
Oil Capacities for Component Replacements    
Accumulator     30 mL (1 fl. oz)    
Compressor     Refer to the Testing and Adjusting, "Refrigerant Compressor Oil-Check"section.    
Condenser    
30 mL (1 fl. oz)    
Evaporator    
90 mL (3 fl. oz)    
In-Liner Dryer (1)    
30 mL (1 fl. oz)    
Receiver - Dryer    
30 mL (1 fl. oz)    
( 1 ) Refer to the Disassembly and Assembly, "In Line Refrigerant Dryer - Remove and Install" before any oil is added.Introduction
Oil supplies the necessary lubrication in the refrigerant circuit for the compressor. Too little oil in the circuit can cause the compressor to seize. Too much oil decreases the amount of cooling that is supplied to the operator.The procedures outlined in this publication describe a process for ensuring the appropriate concentration of oil in the refrigerant circuit when oil has been removed from the circuit. All systems are charged with oil from the factory. This process assumes that the factory fill oil amount is still in the system. This process assumes that a minimal amount of oil has been lost due to leakage of pressure relief. Check of A/C System Oil
Whenever the refrigerant or a component for the air conditioning unit is removed, some of the refrigerant oil is also removed. The correct amount of oil must be replaced. The following three examples are conditions refrigerant oil must be replaced.Note: If oil has leaked from the system prior to service, then the system oil charge cannot be accurately determined. Proper oil charge can now only be determined by flushing and using method for oil charge after system flush. refer to Testing and Adjusting, "Refrigerant System Flush""Oil Charge After System Flush".
(A) Oil that is removed from the system during refrigerant recovery. Refer to Testing and Adjusting, "Refrigerant Recovery" in order to see the correct procedure for recovering refrigerant. Record the amount of oil that is collected during the recovery.
(B) Oil that is removed from the system due to component replacement, other than the A/C compressor. Refer to "Oil Capacities for Component Replacements". Refer to Table 1.
(C) Oil is removed due to replacing the A/C compressor. Refer to "Replacing the A/C Compressor".Replacing a Component
When the replacement of a component is necessary, follow the procedures below.Note: If the failure of a component, causes particles of metal or other foreign material to be introduced into the system. flushing the system will be necessary. Refer to Troubleshooting, "Refrigerant System Flush" to make sure of proper diagnostics. Replacing both the orifice tube and receiver dryer is recommended in the event of A/C system contamination. Flushing of the A/C lines, condenser, and evaporator components will be necessary to safe guard installation of a new compressor. Failure to do so could void component warranties.
If, the A/C system is operable operate the engine at 1000 rpm. Set the temperature on maximum cooling setting. Move the fan speed switch to HIGH. The system will stabilize in a minimum of 10 minutes.
Stop the engine. Remove

Caterpillar SIS machinery equipment:

Caterpillar SIS

Caterpillar parts catalog:

Caterpillar parts catalog
992K Wheel Loader H4C00001-UP (MACHINE) POWERED BY C32 Engine
854K Wheel Dozer 22100001-UP (MACHINE) POWERED BY C32 Engine


Parts option Caterpillar catalog:

Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.