AVSPARE.COM
parts catalog

STRAINER 0002524 - Caterpillar



0002524 STRAINER Caterpillar parts STRAINER
Rating:
26
Alternative (cross code) number:
CA0002524
000-2524
0002524
Caterpillar 0002524 STRAINER

Buy STRAINER 0002524 Caterpillar genuine, new aftermarket tractor parts with delivery

  For full view, you need register

Information:


Illustration 1 g01004979
Schematic of the Action LampTest Step 1. CHECK THE MONITOR PANEL FOR POWER.
Turn the key start switch and the disconnect switch to the ON position.
Disconnect the 12 pin connector from the monitor.
Measure the voltage at the 12 pin connector. Measure the voltage from contact 1 (123-WH) to frame ground.Expected Result:The voltage that is measured is approximately battery voltage.Results:
OK - The voltage that is measured is approximately battery voltage. Proceed to test step 2.
NOT OK - The voltage that is measured is NOT approximately battery voltage.Repair: Check the fuse for the monitor.STOPTest Step 2. CHECK THE HARNESS FOR A SHORT TO THE +BATTERY CIRCUIT.
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the J1 and J2 machine harness connectors from the ECM.
Disconnect the machine harness from the monitor.
At machine harness connector J1 and J2, measure the resistance. Measure the resistance from the signal contact J2-9 (wire J848-BU) to all contacts that are used in the machine harness connectors for the ECM.Expected Result:The resistance should be greater than 5000 ohms for each measurement. Results:
OK - The resistance is greater than 5000 ohms for each measurement. The machine harness is correct. The monitor has failed.Repair: Replace the monitor.STOP
NOT OK - The resistance is NOT correct. There is a short in the machine harness. The short is between signal contact J2-9 (wire J848-BU) and the circuit with the low resistance measurement.Repair: Repair the harness or replace the harness.STOP


Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.