AVSPARE.COM
parts catalog

STRIP 3534594 - Caterpillar



3534594 STRIP Caterpillar parts 621K, 627K, 627K LRC STRIP
Rating:
23
Alternative (cross code) number:
CA3534594
353-4594
3534594
Caterpillar 3534594 STRIP

Buy STRIP 3534594 Caterpillar genuine, new aftermarket tractor parts with delivery
WHEEL TRACTOR-SCRAPER,

Compatible equipment models: 3534594:

WHEEL TRACTOR-SCRAPER  621K   627K   627K LRC   Caterpillar
Number on catalog scheme:
 
  For full view, you need register

Information:


Illustration 1 g00835805
Schematic of the Proportional Solenoid (Tip Back)This diagnostic code is associated with the Tip Back Solenoid. The FMI 03 means that the ECM has determined that the voltage of the solenoid circuit is above normal. The possible causes of the diagnostic code are listed:
The solenoid has failed.
The energize circuit of the solenoid is shorted to the +battery circuit.
The ECM has failed. This is unlikely.Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 0357 FMI 03 is active before performing this procedure.Note: Use the 146-4080 Digital Multimeter for the measurements in this procedure.System Response:The implement system will not operate. The pilot on/off solenoid valve for the implement will de-energize. The levers must be recentered after the diagnostic code is corrected in order to allow the implements to operate.Test Step 1. CHECK THE ENERGIZE CIRCUIT OF THE SOLENOID FOR A SHORT TO THE +BATTERY CIRCUIT.
Turn the key start switch and the disconnect switch to the OFF position.
Disconnect the machine harness connectors from the solenoid and the ECM.
At the machine harness connector for the ECM, measure the resistance from contact J1-17 (wire E921-PK) to all contacts that are used in the machine harness connectors for the ECM. Expected Result:Each resistance measurement is greater than 5000 ohms. Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 2.
NOT OK - Each resistance measurement is not greater than 5000 ohms. There is a short in the machine harness. The short is between J1-17 (E921-PK) and the circuit that has a low resistance measurement. Repair: Repair the machine harness or replace the machine harness. Stop.Test Step 2. CHECK IF THE DIAGNOSTIC CODE IS STILL ACTIVE.
Inspect the contacts and clean the contacts of the harness connectors.
Reconnect all harness connectors.
Turn the disconnect switch and the key start switch to the ON position.
Operate the machine.
Determine if the CID 0357 FMI 03 is active.Expected Result:The CID 0357 FMI 03 is active.Results:
YES - The CID 0357 FMI 03 is active. The problem has not been corrected. The ECM may have failed.Repair: It is unlikely that the ECM has failed. Exit this procedure and perform this procedure again. If the cause of the diagnostic code is not found, replace the ECM. See Testing and Adjusting, "Electronic Control Module (ECM) - Replace". Stop.
NO - The CID 0357 FMI 03 is not active. The problem does not exist at this time.Repair: The initial diagnostic code was probably caused by a poor electrical connection or a short at one of the harness connectors that was disconnected and reconnected. Resume normal machine operation. Stop.

Caterpillar parts catalog:

Caterpillar parts catalog
621K Wheel Tractor-Scraper WTA00001-UP (MACHINE) POWERED BY C13 Engine
627K Wheel Tractor-Scraper WTC00001-UP (MACHINE)
621K Wheel Tractor-Scraper WTL00001-UP (MACHINE) POWERED BY C13 Engine
627K Wheel Tractor-Scraper WTN00001-UP (MACHINE)


Parts strip Caterpillar catalog:

1H2629 STRIP-INSULATION
1090, 1190, 1190T, 120G, 120M, 120M 2, 1290T, 12E, 12G, 12M 2, 12M 3, 12M 3 AWD, 130G, 1390, 140G, 140H, 140M, 140M 2, 140M 3, 140M 3 AWD, 143H, 14E, 14G, 14H, 14M, 16, 160G, 160H, 160M, 160M 2, 160M ...
3448457 STRIP
627H, 627K, 627K LRC
3448458 STRIP
627H, 627K, 627K LRC
6J3599 STRIP
621K, 627K, 627K LRC
4414407 STRIP
621K, 627K, 627K LRC
3286127 STRIP
621K, 627K, 627K LRC
3286128 STRIP
621K, 627K, 627K LRC
3393519 STRIP
621K, 627K, 627K LRC
4389315 STRIP
621K, 627K, 627K LRC
3393519 STRIP
621K, 627K, 627K LRC
3286128 STRIP
621K, 627K, 627K LRC
3286127 STRIP
621K, 627K, 627K LRC
4414407 STRIP
621K, 627K, 627K LRC
6J3599 STRIP
621K, 627K, 627K LRC
5M0101 STRIP
641, 651, 657, 666, 768B, 769
4J8648 STRIP
621, 621B, 627B, 630B, 633, 650B, 666
3971506 STRIP
901C, 902C, 903C
4389315 STRIP
621K, 627K, 627K LRC
Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.