AVSPARE.COM
parts catalog

VALVE GP-PILOT 3472208 - Caterpillar



3472208 VALVE GP-PILOT Caterpillar parts 432E, 434E, 442E, 444E, 525C, 535C, 545C VALVE
Rating:
42
Alternative (cross code) number:
CA3472208
347-2208
3472208
Caterpillar 3472208 VALVE GP-PILOT
Weight: 3 pounds 1 kg.

Buy VALVE GP-PILOT 3472208 Caterpillar genuine, new aftermarket tractor parts with delivery
BACKHOE LOADER, WHEEL SKIDDER,

Compatible equipment models: 3472208:

BACKHOE LOADER  432E   434E   442E   444E  
WHEEL SKIDDER  525C   535C   545C   Caterpillar
Number on catalog scheme: 22
 
  For full view, you need register

Information:


Illustration 1 g01206575
Schematic of the Solenoid Valves (Ride Control)This diagnostic code is associated with the Ride Control Solenoid Valve #3. The FMI 03 means that the ECM has determined that the voltage of the circuit for Ride Control Solenoid Valve #3 is above normal.The possible causes of the diagnostic code are listed:
Ride Control Solenoid Valve #3 has failed.
The energize circuit of Ride Control Solenoid Valve #3 is shorted to the +battery circuit.
The ECM has failed. This is unlikely.Note: The following test procedure may create other diagnostic codes. Ignore these created diagnostic codes and clear these diagnostic codes when the original diagnostic code has been corrected. Ensure that the diagnostic code of CID 2684 FMI 03 is active before performing this procedure.Note: Use the 146-4080 Digital Multimeter for the measurements in this procedure.System Response:When this diagnostic code occurs, the ride control function will stick in a balance position. The other two ride control solenoids are not energized. The operator does not have ride control that is independent of the switch setting.Test Step 1. CHECK THE SOLENOID.
Turn the disconnect switch and the key start switch to the ON position. Do not start the engine.
Disconnect the Ride Control Solenoid Valve #3 from the machine harness.
At the machine harness connector for the solenoid, place a jumper wire from contact 2 to contact 1.
Observe the status of the CID 2684 FMI 03.Expected Result:The CID 2684 FMI 03 remains active. The FMI has not changed and the "03" is still active.Results:
YES - The diagnostic code remains active. The jumper wire does not affect the diagnostic code. Proceed to Test Step 2.
NO - The diagnostic is no longer active. The solenoid has failed.Repair: The solenoid has failed. Repeat this Test Step "CHECK THE SOLENOID" in order to verify the solenoid failure. Replace the solenoid. Verify that the new solenoid corrects the problem.STOPTest Step 2. CHECK THE ENERGIZE CIRCUIT OF THE SOLENOID FOR A SHORT TO THE +BATTERY CIRCUIT.
Turn the key start switch and the disconnect switch to the OFF position.
The Ride Control Solenoid Valve #3 remains disconnected from the machine harness.
Disconnect the machine harness connector(s) from the ECM.
At the machine harness connector for the ECM, measure the resistance from contact J2-3 (wire A958-WH) to all contacts that are used in the machine harness connectors for the ECM.Expected Result:Each resistance measurement is greater than 5000 ohms.Results:
OK - Each resistance measurement is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 3.
NOT OK - Each resistance measurement is not greater than 5000 ohms. There is a short in the machine harness. The short is between J2-3 and the circuit that has a low resistance measurement.Repair: Repair the machine harness or replace the machine harness.STOPTest Step 3. CHECK IF THE DIAGNOSTIC CODE IS STILL ACTIVE.
Inspect the contacts and clean the contacts of the harness connectors.
Reconnect all harness connectors.
Turn the disconnect switch and the key start switch to the ON position.
Operate the machine.
Determine if the CID 2684 FMI 03 is active.Expected Result:The CID 2684 FMI 03

Caterpillar parts catalog:

Caterpillar parts catalog
442E Backhoe Loader EME00001-UP (MACHINE) POWERED BY C4.4 Engine
444E Backhoe Loader NBA00001-UP (MACHINE) POWERED BY C4.4 Engine
434E Backhoe Loader SJL00001-UP (MACHINE) POWERED BY C4.4 Engine
432E Backhoe Loader JBA00001-UP (MACHINE) POWERED BY C4.4 Engine
545C Wheel Skidder 54500001-UP (MACHINE) POWERED BY C7 Engine
535C Wheel Skidder 53500001-UP (MACHINE) POWERED BY C7 Engine
525C Wheel Skidder 52500001-UP (MACHINE) POWERED BY C7 Engine


Parts valve Caterpillar catalog:

9T0704 VALVE GP-RELIEF
416B, 416C, 416D, 420D, 424D, 426B, 426C, 428, 428B, 428C, 428D, 430D, 436C, 438B, 438C, 438D, 446, 446B, 446D, 515, 517, 525, 525B, 525C, 527, 535B, 535C, 545, 545C, D4H, D4H XL, D5H, D5H XL, D5M, D6...
3E4058 VALVE AS
1090, 1190, 1190T, 120G, 120H, 120H ES, 120H NA, 120M, 1290T, 12G, 12H ES, 12H NA, 12M, 130G, 135H, 135H NA, 1390, 140G, 140H ES, 140H NA, 143H, 14H, 14H NA, 160H ES, 160H NA, 163H NA, 16G, 16H NA, 16...
8F8151 VALVE-SHUTOFF
1090, 1190, 1190T, 120, 120B, 120G, 120H, 120H ES, 120H NA, 1290T, 12F, 12G, 12H, 12H NA, 130G, 135H, 135H NA, 1390, 140, 140B, 140G, 140H, 140H NA, 143H, 14E, 14H, 16, 160H, 163H, 16G, 16H NA, 16M, 2...
6V7238 VALVE-SHUTOFF
1090, 1190, 1190T, 120K, 120K 2, 120M, 120M 2, 1290T, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 1390, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160K, 160M, 160M 2, 160M 3, 160M 3 AWD, 16M, 214B, 2...
1766219 VALVE GP-SOLENOID
3054, 3054B, 3054C, 3056, 315, 317, 414E, 416D, 416E, 416F, 420D, 420E, 420F, 422E, 422F, 424D, 428D, 428E, 428F, 430D, 430E, 430F, 432D, 432E, 432F, 434E, 434F, 438D, 442D, 442E, 444E, 444F, 908, AP-...
2255495 VALVE-INLET
3054C, 3054E, 312D2, 312D2 GC, 312D2 L, 313D2, 313D2 LGP, 315C, 318D2 L, 414E, 416D, 416E, 416F, 420D, 420E, 420F, 422E, 422F, 424D, 428D, 428E, 428F, 430D, 430E, 430F, 432D, 432E, 432F, 434E, 434F, 4...
2255499 VALVE-EXHAUST
3054C, 3054E, 312D2, 312D2 GC, 312D2 L, 313D2, 313D2 LGP, 315C, 318D2 L, 414E, 416D, 416E, 416F, 420D, 420E, 420F, 422E, 422F, 424D, 428D, 428E, 428F, 430D, 430E, 430F, 432D, 432E, 432F, 434E, 434F, 4...
1645590 VALVE GP-FLUID SAMPLING
1090, 1190, 1190T, 120H, 120H ES, 120H NA, 120K, 120K 2, 1290T, 12H, 12K, 135H, 135H NA, 1390, 140H, 140K, 140K 2, 143H, 14H, 160H, 160K, 163H, 16H, 216B, 216B3, 226B, 226B3, 2290, 232B, 236B, 236B3, ...
1549023 VALVE-SAMPLING
1090, 1190, 1190T, 120H, 120K, 120K 2, 1290T, 12K, 12M, 12M 2, 12M 3, 12M 3 AWD, 135H, 1390, 140G, 140K, 140K 2, 140M, 140M 2, 140M 3, 140M 3 AWD, 14M, 160K, 160M 2, 160M 3, 160M 3 AWD, 16M, 236D, 242...
3K6905 VALVE-BREATHER
140G, 3126, 3126B, 3208, 3412, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 3606, 3608, 3612, 3616, 5130, 5130B, 515, 518, 5230, 5230B, 525, 525B, 525C, 525D, 528, 528B, 530B, 533, 535B...
6U1989 VALVE-RELIEF
3406, 3406B, 3406C, 3408, 3408C, 3408E, 3412, 3412C, 3412E, 3508, 3508B, 3508C, 3512, 3512B, 3512C, 3516, 3516B, 3516C, 515, 525, 525B, 525C, 535B, 535C, 545, 545C, 583T, 587R, 587T, 623G, 627G, 627H,...
1478211 VALVE-EXHAUST
120H, 120K, 120K 2, 12K, 12M, 135H, 140G, 140K, 140K 2, 140M, 160K, 3126, 3126B, 3126E, 322C, 322C FM, 324D, 324D FM, 324D FM LL, 324D L, 324D LN, 325C, 325C FM, 325D, 325D FM, 325D FM LL, 325D L, 325...
3471129 VALVE GP-LOAD CONTROL
432E, 432F, 434E, 442E, 444E, 444F
3471128 VALVE GP-LOAD CONTROL
432E, 432F, 434E, 442E, 444E, 444F
3417658 VALVE GP-RELIEF
246D, 262D, 277D, 279C, 279D, 287D, 289C, 289D, 299D, 299D XHP, CB-44B, CB-54B, CD-54B, CW-34
3282162 VALVE GP-SOLENOID
272D XHP, 299D XHP, 420E, HM312, HM315, HM415B, T9B
1681773 VALVE AS
420E, CB-544, CB-545, D7E, D7E LGP, SG16, SG16B
3596658 VALVE GP-CHECK
432E, 434E, 442E, 444E
Back to top
The names Cat, Caterpillar, John Deere, Komatsu, Volvo, Hitachi, Doosan, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
AVSpare.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only. Cat® and Caterpillar® are registered trademarks of Caterpillar, Inc.